South Florida
Kohler Generator Won't Start? Causes, Checks and Common Problems
A Kohler generator that cranks but won't start, or won't crank at all, usually comes down to fuel, air, compression or electrical. Here is what our mobile mechanics check first, plus the other problems we see most on Kohler generator equipment.
South Florida
Why a Kohler Generator Won't Start
Dead or weak batteries and corroded cables, a failed starter or relay, air in the fuel system, clogged fuel filters, a bad lift pump, seat and neutral safety switches, glow plug or intake heater faults, and low compression on high-hour engines. Other searches we hear about Kohler generator: won't start, will not start, starts then dies.
600+
Service Calls Per Year
282
Reoccurring Clients
Kohler Diagnostics
Engine, alternator and control panel faults on the Kohler generator diagnosed on site, with load testing where needed.
Kohler No-Start & Shutdown Repair
Fuel, battery, starter, low-oil and overheat shutdowns on the Kohler generator traced and repaired.
Kohler Fuel System Repair
Injectors, pumps, filters and contaminated fuel problems on the Kohler generator corrected.
Kohler Cooling System Repair
Radiators, water pumps, thermostats and fans on the Kohler generator repaired.
Kohler Control Panel & ATS
Controllers, sensors, wiring and transfer switch faults on the Kohler generator repaired.
Kohler Charging & Batteries
Battery chargers, alternators and batteries on the Kohler generator tested and replaced.
Kohler Load Bank Testing
Load testing confirms the Kohler generator carries its rated load before you need it.
Kohler Scheduled Service
Oil, filters, coolant, belts and exercise checks on the Kohler generator on a schedule.
Engine
Diesel or gas engine repair on the Kohler generator.
Alternator / Generator End
Output and winding fault repair.
Control Panel
Controller and sensor repair on the Kohler generator.
Transfer Switch
ATS repair and testing.
Fuel System
Injector, pump and filter repair.
Cooling System
Radiator and water pump repair.
Batteries & Charger
Starting system service.
Governor & Voltage Regulator
Speed and voltage control repair.
Enclosure & Exhaust
Housing, muffler and exhaust repair.
CITY
Reach Out?
Need service for your heavy equipment? Our mobile diesel mechanics provide on-site diagnostics, engine repair, hydraulic service, and drivetrain repairs to keep your machines running with minimal downtime.
Yes. Our diesel mechanics provide mobile, on-site heavy equipment repair throughout South Florida. We service equipment directly at job sites to reduce downtime and avoid unnecessary transport.
We repair a wide range of heavy equipment, including excavators, loaders, backhoes, skid steers, dozers, agricultural machinery, and other diesel-powered equipment used in construction and industrial operations.
Response times vary based on location and workload, but our mobile diesel mechanics aim to provide prompt service to diagnose and repair equipment as efficiently as possible.